Tag Archives: Tank car retirement

New Oil Train Safety Regs Focus on Accident Response, Not Prevention

Repost from Center for Biological Diversity

CenterForBiolDiv_logoNew Oil Train Safety Regs Focus on Accident Response, Not Prevention

Long Phase-out of Hazardous Cars, Inadequate Speed Limits Leave Communities at Risk of Explosive Derailments

For Immediate Release, December 7, 2015
Contact: Jared Margolis, (802) 310-4054

WASHINGTON— A new transportation bill signed by President Obama includes provisions intended to improve the safety of oil trains, but leaves puncture-prone tank cars in service for years and fails to address the speed, length and weight of trains that experts point to as the leading causes of explosive derailments. The bill upgrades safety features on oil train tank cars and requires railroads to provide emergency responders with real-time information about when and where dangerous oil cargoes are being transported but doesn’t do enough to prevent oil train accidents, which have risen sharply in recent years.

“While these regulations improve our ability to prepare for oil train disasters they do virtually nothing to prevent them from ever occurring in the first place,” said Jared Margolis, an attorney with the Center for Biological Diversity who focuses on the impacts of energy development on endangered species. “Until we dramatically reduce the speed and length of these bomb trains it’s only a matter of time before the next explosive derailment sends fireballs rolling through one of our communities.”

The new regulations will require all oil train tank cars to include fire-resistant ceramic coatings and protections for protruding top fittings. The final rule issued by federal regulators in May only required oil trains with 35 loaded oil tank cars or 20-car blocks of oil tank cars to implement the new standards, and would not have required the ceramic blankets or top fitting protections for all retrofitted cars.

But experts say even the protective measures included in the new transportation regulations signed into law on Friday will do little to prevent a spill if a train derails at speeds faster than 18 mph, and oil trains are permitted to travel at 40 mph to 50 mph. And the new regulations do not require the phase-out of dangerous puncture-prone tank cars to begin until 2018, and allows them to remain in service until 2029.

“It’s irresponsible to continue to allow these bomb trains to roll through the middle of our communities and across some our most pristine landscapes,” said Margolis. “We need to quit pretending we can make these dangerous trains safe and simply ban them altogether.”

Congress has directed the U.S. Department of Transportation to continue requiring notifications to states of train routes and frequencies so communities can better prepare to respond to train derailments, explosions and oil spills. However, the new regulations do nothing to remedy the track infrastructure problems, or the excessive length and weight of oil trains, cited as leading causes of derailments. Further, it remains unclear whether the public will have access to information about these hazards.

“Keeping information on oil trains from public scrutiny is outrageous, and only serves to protect the corporate interests that care little about the risk to the homes, schools and wild areas that these trains threaten,” said Margolis. “We need to keep these trains off the tracks and keep these dangerous fossil fuels in the ground, rather than keeping the public in the dark.”

Background 

The National Transportation Safety Board has repeatedly found that current tank cars are prone to puncture on impact, spilling oil and often triggering destructive fires and explosions. But federal regulators have ignored the safety board’s official recommendation to stop shipping crude oil in the hazardous tank cars. Recent derailments and explosions have made clear that even the newer tank cars, known as CPC-1232s, are not significantly safer, often puncturing at low speeds.

The recent surge in U.S. and Canadian oil production, much of it from Bakken shale and Alberta tar sands, has led to a more than 4,000 percent increase in crude oil shipped by rail since 2005, primarily in trains with as many as 120 oil cars that are more than 1.5 miles long. The result has been oil spills, destructive fires, and explosions when oil trains have derailed. More oil spilled in train accidents just in 2013 than in the 38 years from 1975 to 2012 combined.

The Center for Biological Diversity is a national, nonprofit conservation organization with more than 900,000 members and online activists dedicated to the protection of endangered species and wild places.

    AP: Railroads beat back new safety rules after derailments

    Repost from the Boston Herald

    AP: Railroads beat back new safety rules after derailments

    By Matthew Brown and Michael Kunzelman, December 05, 2015
    FILE -In this Monday, Feb. 23, 2015, file photo, clean up continues near Mount Carbon, W.Va., where a train derailed and sent a tanker with crude oil into the Kanawha River. A little-known truth about North American railroads: No rules govern when rail becomes too worn down. Since 2000, U.S. officials blamed rail wear as the direct cause of 111 derailments causing $11 million in damage. (AP Photo/Chris Tilley, File)

    A pair of train derailments in 2012 that killed two people in Maryland and triggered a fiery explosion in Ohio exposed a little-known and unsettling truth about railroads in the U.S. and Canada: No rules govern when rail becomes too worn down to be used for hauling hazardous chemicals, thousands of tons of freight or myriad other products on almost 170,000 miles of track.

    U.S. transportation officials moved to establish universal standards for when such steel gets replaced, but resistance from major freight railroads killed that bid, according to Associated Press interviews with U.S. and Canadian transportation officials, industry representatives and safety investigators.

    Now, following yet another major accident linked to worn-out rails — 27 tanker cars carrying crude oil that derailed and exploded in West Virginia earlier this year — regulators are reviving the prospect of new rules for worn rails and vowing they won’t allow the industry to sideline their efforts.

    “We try to look at absolutely every place where we can affect and improve safety,” said Federal Railroad Administrator Sarah Feinberg. “Track generally is the place that we’re focusing at the moment, and it’s clearly overdue. Rail head wear is one place in particular that we feel like needs to be addressed as soon as possible.”

    An official announcement on the agency’s intentions to revisit rail wear is expected by the end of the year.

    In the meantime, federal regulators haven’t taken the positive steps that they need to, said Ronald Goldman, an attorney for the families of the two 19-year-old women who died in a 2012 derailment outside Baltimore.

    “It’s a lack of will, not a lack of ability, in my opinion,” he added.

    Industry supporters argue that the seven major freight railroads in the U.S. and Canada are in the best position to know what is going on with their lines, including when they need to be replaced or have the maximum speeds for trains traveling on them lowered. They also note a long-term decline in accidents that has reduced the frequency of derailments by more than 40 percent since 2000.

    All sides agree it’s difficult to pinpoint how many accidents are tied to worn rail. Since 2000, U.S. officials blamed rail wear as the direct cause of 111 derailments causing $11 million in damage.

    That’s less than 1 percent of all accidents, yet it masks a broader safety dilemma: Years of massive loads rolling over a rail will exacerbate defects in the steel, such as cracks or fractures. Investigators ultimately list the defect as the cause of a derailment, but it might never have been a problem if the rail had not been worn down.

    “Rail defects are internal and rail wear is external, and when external meets internal, that’s when problems may arise,” said John Zuspan of Track Guy Consultants, a Pennsylvania firm that offers track inspections, safety training and other services for railroads.

    Two accident causes in particular have the strongest correlation with worn-out rails: “detail fractures” that result from fatigued metal, and “vertical splits” in the head of the rail, where it makes contact with a train’s wheels, according to the FRA.

    Those problems caused a combined 1,200 derailments with $300 million in damages, three deaths and 29 people injured in the U.S. between 2000 and the present, according to accident records reviewed by the AP.

    Among them was the July 2012 derailment of a Norfolk Southern Railway train hauling ethanol and other products through Columbus, Ohio. Seventeen cars derailed, including three hauling highly flammable ethanol that exploded into flames, triggering an evacuation of surrounding neighborhoods.

    A month later, another accident occurred involving a CSX Transportation train hauling coal over a bridge along Main Street in Ellicott City, Maryland, outside Baltimore. Twenty-one cars derailed when the company’s worn-down rail split beneath the weight of the coal cars. The two college students sitting on the bridge died, crushed by thousands of pounds of spilled coal.

    The victims’ families reached a settlement with CSX last year for undisclosed terms. Goldman, the families’ attorney, said he pressed federal officials for a forum that would allow his clients to testify about the issue, but “nothing really happened.”

    A month after the CSX derailment, federal regulators asked the Rail Safety Advisory Committee — a panel created by the Railroad Administration to include the industry and others in fashioning safety rules — to craft new standards to reduce the risks of worn-down rail. The committee set up a 116-person working group to tackle the problem, made up of industry representatives, government officials, consultants, researchers and railroad worker unions.

    The group included 55 representatives from the major freight railroads and their industry organization, the Association of American Railroads. The FRA had 14 seats at the table and their counterparts from Transport Canada had five.

    Following several meetings in 2012 and 2013, the group — which required consensus before recommending action — agreed on voluntary guidance for companies to manage rail wear, but no new regulations.

    “There was certainly a lot of pushback and a lot of political pressure put on FRA not to adopt regulations for rail wear,” said Richard Inclima, director of safety for the union that represents track inspectors and a member of the working group. “Rail wear limits were on the table. The industry raised a lot of arguments against rail wear limits.”

    “The industry doesn’t want to be regulated,” he added. “That’s no secret.”

    The railroads’ opposition was confirmed by others involved with the group’s work including from the National Transportation Safety Board, the FRA and Transport Canada.

    Association of American Railroads spokesman Ed Greenberg said the railroads were “unaware of any science-based data supporting rail wear limits.”

    NTSB investigator Richard Hipskind, who took part in the Ellicott City and Columbus accident investigations and later served on the rail wear working group, said more research would be needed to establish universal standards.

    Railroads have their own internal standards for rail wear, and have replaced more than 30,000 miles of rail since 2010, according to reports submitted by the major railroads to the U.S Surface Transportation Board, a semiautonomous agency under the umbrella of the U.S. Department of Transportation.

    Standards vary among railroads and are complicated by differences in how much weight a given line bears, whether it’s in a wet or dry climate, and if the line goes through mountains or involves lots of turns. Those variables can make the difference between well-worn rail that’s still safe and routes that poses a heightened safety hazard, according to industry experts and safety officials.

    Greenberg said the industry takes an aggressive approach to identifying and removing defective or worn sections of rail.

    “Each railroad has its distinct operating environment and operating conditions that would be factored into this,” Greenberg said. He added that the industry was now interested in “renewed dialogue” with the FRA on the topic.

    The AP requested details on rail wear standards from each of the seven major freight railroads — BNSF Railway, Union Pacific, Canadian Pacific, CSX, Canadian National, Norfolk Southern and Kansas City Southern. They either refused the request or referred questions to the railroad association, which also declined to release the standards.

    Public attention to train derailments increased sharply after July 2013, when an out-of-control oil train derailed and exploded in Lac-Megantic, Quebec, killing 47 people. One of the most significant changes to emerge from that and other accidents involving crude and ethanol was a mandate for companies to phase out or upgrade tens of thousands of tank cars that are prone to rupture.

    Those are important changes, said James Horbay, a rail safety engineer with Transport Canada. But what causes trains to come off the tracks in the first place needs to be resolved, he said.

    “If you crash an airplane, are you going to say, ‘Let’s build an airplane that’s not going to fall apart when it hits the ground?'” he asked. “Whether rail wear is something that should be looked at is a good question to ask. You’re going right to the cause now.”


    Matthew Brown reported from Billings, Montana.  Michael Kunzelman reported from Baton Rouge, Louisiana. 

      First National Conference on Oil Train Threats – excellent report by Justin Mikulka

      Repost from DeSmogBlog
      [Editor:  Many thanks to Justin Mikulka for this excellent report on “Oil Train Response 2015,” nicely summarizing the important issues as well as the event.   Great photo below – click on it to enlarge so you can play Where’s Waldo.  🙂  For a local media report and some good links, see also my earlier posting.  – RS]

      “We Need Not Be Polite” Hears First National Conference On Oil Train Threats

      By Justin Mikulka • Wednesday, November 25, 2015 – 03:58
      oil train conference
      Oil Train Response 2015, 1st national conference on oil train threats, 11/14-15/15, Pittsburgh

      On November 12th, I boarded a train headed to Pittsburgh, PA to attend the first national independent gathering focused on the topic of oil trains. The trip would take me through Philadelphia where an Amtrak train crashed in May resulting in eight fatalities and over 200 injuries.

      There is general consensus that the accident would have been avoided if positive train control technology had been in place. In 2008, Congress mandated that positive train control be installed by the end of 2015. However, the railroads failed to do this and were recently given a three to five year extension by Congress after the rail companies threatened to shut down rail service if the mandate were enforced.

      It is a reminder of the power of the rail lobbyists. Another example of this power is currently playing out in Congress. Earlier this year, the Senate voted to raise the amount of money that could go to victims of accidents such as the one in May. However, rail lobbyists and members of Congress are working to strip this change out of pending legislation.

      Having covered the topic of oil trains for the past two years, none of this is surprising. The rail and oil lobbyists have been very effective at weakening new oil-by-rail regulations and achieving huge delays for any actual implementation of these changes.

      In 2013, an oil train full of Bakken crude oil derailed in Lac-Megantic resulting in a fire that killed 47 people. The existing regulations will allow trains like the one in Lac-Megantic to roll on the rails until 2023.

      These known risks and lack of regulations have created new activists across the continent and the Oil Train Response 2015 conference was the first time they have all come together in one place to discuss the issue and organize together. The event was sponsored and organized by The Heinz FoundationFracTracker and ForestEthics.

      The first day of the conference was designed to inform the attendees about various aspects of oil-by-rail transportation and included presentations from first responders, politicians, Riverkeepers, legal experts and railroad safety consultant Fred Millar.

      What You Are Up Against

      Ben Stuckart is president of the Spokane city council, a city currently seeing 15 oil trains a week and facing the potential of as many as 137 a week by 2020 by some estimates. During his presentation, Stuckart described a trip he took to Washington, D.C. to meet with Secretary of Transportation Anthony Foxx to express his concerns about the oil trains.

      “We sit down and we’re talking to him and he’s like ‘well here is what you are up against.’ He goes, ‘My first day in office.  BNSF and Union Pacific just showed up and walked into our office.’ And he asked up front what’s going on, I don’t have an appointment. ‘Oh there is an open door policy.’

      The railroads have an open door policy. Do you know how long it took for me to get an appointment with transportation secretary Foxx?”

      This isn’t the only time Secretary Foxx learned what we “are up against.”

      Earlier this year, Reuters reported that when the White House was finalizing the new regulations, Secretary Foxx requested that the regulations address the volatility of Bakken crude oil. His request was denied.

      Stuckart’s recounting of Foxx’s candid explanation of the reality of regulation in Washington, D.C. is an excellent example of the power of the industry, and provides insight into why these trains continue to run despite the known risks.

      We Need Not Be Polite

      Much of the morning session of the first day of the conference was devoted to emergency response, featuring three different presentations on the topic. A bit later, rail safety consultant Fred Millar took to the podium and wasted no time in getting everyone’s attention. With the earlier emergency response presenters flanking him on either side of the podium, Millar did not pull any punches.

      “We need not be polite with the railroads and first responders,” Millar said. And then he proceeded to point out what a farce the idea of emergency response planning is regarding Bakken oil trains.

      “It’s a lie,” Millar said as he showed a slide of emergency responders operating fire hoses standing very near a black rail tank car that was on fire. Millar noted that these are public relations efforts meant to calm the public, but the reality of a Bakken oil train accident is that everyone within a half mile is evacuated and the train is allowed to burn itself out because it is too dangerous for first responders to approach. Often the fires last for days.

      Millar’s presentation was enthusiastically received by the conference audience. As he delivered one of his many hard-hitting lines to applause, an audience member could be heard saying, “He’s like a preacher up there!” However, as repeatedly noted in his presentation, his opinion is that very little is being done to address the risks of oil-by-rail transportation.

      They Are Our Children

      Things got a bit heated in the question and answer session following Millar’s presentation. One point of contention was that the first responders maintained that they need to keep information about oil trains secret so as to not help out “the bad guys” — an idea not well received by the many people in the audience living near oil train tracks.

      Raymond DeMichiei, Pittsburgh’s Deputy Coordinator of Emergency Management, sparked the biggest outcry when he stated that he didn’t see why “people need to know how many daycare centers are within the blast zone.” Among the responses was a woman yelling, “They are our children!”

      As the session came to a close, a frustrated DeMichiei said, “Get ’em off the rails. I’ll be a happy guy.”  It was one point that everyone in the room could agree on.

      FRA Administrator Grateful For Luck

      A week before the conference, an ethanol train derailed in Wisconsin and spilled ethanol into the Mississippi River. The next day, an oil train derailed and spilled oil in a residential neighborhood in Wisconsin. On the first day of the conference, news broke that an oil train derailed near Philadelphia, although there was no spill.

      Sarah Feinberg, head of the Federal Railroad Administration, commented on the accidents in Wisconsin saying, “We feel we got really lucky.” When I pointed out on Twitter that luck is currently a big part of the oil train safety plan, she responded.

      While it is true that regulators are taking many steps to improve safety, it is also true that the oil and rail industries are working hard against any real improvements to safety. The dangerous oil is not being stabilized. The unsafe tank cars will be on the rails for at least eight more years. Modernized braking systems are years away and the industry is fighting that as well. And trains continue to run through many large cities.

      On my train ride home from the conference, I saw many of the signature black tank cars on the rails. Some were carrying liquid petroleum gas, some ethanol and at least one was a unit train of oil cars (although likely empty as it was traveling West). The potential of an accident involving a commuter train and an oil train didn’t seem far fetched.

      View from Amtrak train, photo by Justin Mikulka.

      A National Movement Begins

      The people gathered in Pittsburgh don’t want to rely on luck to protect their communities. They are committed to fighting for real rail safety, and they were clearly energized by this event. As Ben Stuckart said, “This is so awesome. I haven’t seen this big of a group about this very specific issue since I’ve been working on it the last four years.”

      And that is good news for the 25 million people currently living within bomb train blast zones. Because if there is one lesson learned from the long delay over the implementation of positive train control, it is that this battle is likely to be a long and difficult effort.

      Blog image credit: Paul Anderson