Category Archives: Rail inspection

Crude By Rail, DOT-111, Emergency Readiness & Response, Federal Regulation (U.S.), Hazmat notification, Local Regulation, Massive increase in crude-by-rail, Positive Train Control, Rail inspection, Rail routing, Risk Assessment, State regulation, Train speed

Law professor: 9 ways that STATES can help regulate railroad safety and transportation

Repost from LegalPlanet.org
[Editor:  Federal preemption under the Commerce Clause is NOT the last and only word on regulating crude oil trains.  Here are some suggestions for State regulation by Professor Jayni Foley Hein, executive director of UC Berkeley School of Law’s Center for Law, Energy & the Environment.  – RS]

Oil By Rail: Nine Things California Can Do to Increase Safety

While FRA Considers New Federal Regulations, States Can Ramp Up Prevention and Emergency Response
By Jayni Hein, June 24, 2014

At a joint Senate and Assembly hearing last week on oil by rail safety in California, some lawmakers expressed frustration at slow federal action, and asked what California can do to increase public safety. My testimony focused on federal preemption issues, defining areas where the state can regulate, and those where it is preempted by the Commerce Clause, Federal Railroad Safety Act (FRSA), or ICC Termination Act, or all three.

While the Department of Transportation (DOT) and Federal Railroad Administration (FRA) have primary authority over railroad safety and transportation, the California Public Utilities Commission (CPUC) shares authority with the federal government to enforce federal rail safety requirements and conduct inspections. And even with strong federal preemption provisions, there are actions that California and other states can take right now to increase public safety in light of the enormous growth of oil by rail.

Here are nine things the state can do:

1. Prioritize track and rail car inspection.

California has more than 5,000 miles of mainline railroad track. Inspection of track and rail cars is vital, as derailments are the most common type of train accident in the United States. A national analysis of freight train derailments from 2001 to 2010 on the Class I freight railroads’ mainline track found that broken track rails or track welds were the leading cause of derailments. Broken rail car wheels and track obstructions are also common causes of derailments. (Liu, et. al. 2012).

Governor Brown’s new budget includes funding to hire seven additional rail safety inspectors for the CPUC, paid for by rail industry assessments. The state should ensure that it has enough CPUC inspectors to accommodate the projected rise in oil by rail traffic each year. If seven new inspectors are needed right now; we will likely need many more by 2016, when oil by rail shipments are projected to increase as much as 25-fold, to 150 million barrels per year.

2. Obtain robust data on rail routing, rail car contents, and accident causes.

California agencies need more information from FRA and the railroads on routes, frequency, and rail car contents, as well as data on train derailments, their causes, and risk factors specific to crude by rail transit. The state should obtain this data from FRA – a recommendation echoed in the June 10, 2014 California Inter-Agency Working Group Report. The CPUC needs both national data and California-specific data in order to do its job.

3. Conduct an analysis of the risks that crude by rail poses to the state, including identification of high-risk areas of track, and propose specific measures to increase safety.

The legislature should consider requiring an annual report from the CPUC on the specific risks that crude by rail poses to the state, and measures that it can take to increase safety. Voluntary agreements with the railroads may also be an important outgrowth of this state-specific analysis that can inform where and how to direct limited state resources. As previewed above, this state analysis should be guided by the most recent data available from FRA and the railroads.

The legislature could also consider requiring information sharing among the relevant state agencies, including CPUC, Office of Emergency Services (OES), Office of Spill Prevention and Response (OSPR), California Environmental Protection Agency, and more.

4. Require state oil spill contingency plans for trains transporting oil into the state.

SB 1319 (Pavley) would require state oil spill contingency plans for trains transporting oil into the state. Such a state-mandated plan would provide an opportunity to secure better emergency response protection for the environment and public safety.

5. Get access to daily information on oil shipments into California, and ensure that state and local emergency personnel can access this information immediately in the event of an accident.

A recent DOT Emergency Order requires that each railroad operating trains containing more than 1 million gallons of Bakken crude oil, or approximately 35 tank cars, to provide states with weekly notice that includes estimated volumes of Bakken oil  transported per week and routing information.

The state should also have immediate access to real-time shipment information, assuming the technology exists to enable this. The state should also ensure that local emergency response personnel are well trained to deal with any crude by rail accident, and can readily identify the contents of any shipment. Training and information sharing with local emergency response personnel can be paid for by the industry, using a fee or assessment like the 6.5 cent/barrel fee on all oil imports recently approved by the state.

6. Advocate for more stringent federal safety regulations.

Legislative pronouncements, as well as the CPUC’s robust participation in the Rail Safety Advisory Committee (RSAC) are needed to secure better federal standards.

California joins others states such as New York in advocating for more stringent rail car design standards (phasing out DOT-111 cars, for example), mandatory placards on rail cars identifying Bakken crude oil,  expediting Positive Train Control, and requiring electronically-controlled pneumatic brakes on all crude oil trains. The state can also advocate for further federal analysis of possible routing changes, to avoid sensitive population and habitat areas.

7. Monitor compliance with new voluntary measures that the railroads agreed to implement this year.

As part of a February 2014 agreement with DOT, the Class I railroads will perform one additional internal-rail inspection each year than required by the FRA on routes over which trains carry 20 or more tank cars of crude oil, and will conduct at least two track geometry inspections over these routes. The  railroads also agreed to use end-of-train braking systems on all oil trains, and lower train speed in federally-designated “high-threat-urban-areas.”

The CPUC should monitor the railroads’ compliance with these voluntary measures. At the same time, CPUC and the state should advocate for making these voluntary measures mandatory, by issuing new or revised FRA regulations.

8. Consider issuing guidance to local permitting agencies on requirements for offloading facilities and oil refinery expansion.

There are currently at least five crude-by-rail refinery projects being pursued in California: one in Pittsburg, one in Benicia, two in Bakersfield, and one in Wilmington. There is a patchwork of local permitting agencies responsible for land use, air, water, and other local safety and environmental issues that may be relevant to offloading sites and refineries.

Local government and permitting agencies can deny land use and other permits for refineries and offloading facilities if they find safety risks or improper environmental mitigation under statutes like the California Environmental Quality Act (CEQA). But, local agency personnel may have varying levels of expertise in oil and rail issues and may apply permitting criteria inconsistently. As such, the state, through the Office or Planning and Research (OPR), should consider issuing guidance to local permitting agencies on necessary permits and requirements for offloading facility or refinery expansion.

9. Provide guidance on CEQA review and the public comment and participation process, especially relevant to environmental justice communities that may be located near offloading sites or refineries.

While rail accidents can happen anywhere, communities near offloading sites and refineries are especially vulnerable to oil by rail transport risks. The state can provide information and guidance to these communities on opportunities for engagement, comment and participation.

In addition, the state can encourage railroads, industry and refineries to work directly with potentially affected communities to disclose as much information as possible about shipments, safety measures, and how community members can participate in the process to make their communities safer.

Bakken Crude, California Regulation, Crude By Rail, Emergency Readiness & Response, Federal Regulation (U.S.), Massive increase in crude-by-rail, Rail inspection, Tank car design, Train speed

Public Radio: Lawmakers Seek Ways to Address Oil Train Risks

Repost from Capital Public Radio News
[Editor: About halfway through this 2-minute Public Radio report, UC Berkeley Law professor Jayni Hein offers several ways in which state regulators CAN make effective contributions to public health and safety.  The 3-hour California Joint Legislative Oversight Hearing on Transport of California Crude Oil by Rail  can be viewed here.  – RS]

Lawmakers Seek Ways to Address Oil Train Risks

California Update
By Mark Prell & Capital Public Radio News , June 20, 2014

California lawmakers are taking a closer look at the risks posed by importing crude oil by rail. At issue is what the state can do to prevent and respond to oil rail accidents when so much regulation happens at the federal level.

Audio Report – LISTEN

Bakken Crude, Capitol Corridor, Crude By Rail, DEIR, Derailment, DOT-111, Emergency Readiness & Response, Explosion, Federal Regulation (U.S.), Hazmat notification, Local Regulation, Massive increase in crude-by-rail, Rail accidents, Rail inspection, Rail routing, Risk Assessment, Spill prevention and response, Tank car design, Train speed, Valero Benicia Refinery

Sacramento Bee: NRDC report – thousands face the risk of crude oil train spills

Repost from The Sacramento Bee

Advocacy group: Thousands in Sacramento face the risk of crude oil train spills

by Tony Bizjak  |  June 19, 2014

More than 135,000 Sacramentans live within a half-mile of rail tracks and could find themselves in harm’s way should a crude oil train derailment cause a spill, according to a report published Wednesday by the Natural Resources Defense Council in California. The group’s maps show 25,000 residents in Davis within a half-mile of train tracks.

The NRDC study includes maps of rail lines through seven California cities, showing areas likely to require evacuation in case of serious rail incident. It is unclear which lines might carry crude oil trains. Oil companies and railroads closely guard information about crude oil rail movements. NRDC said its analysis of a handful of oil company refinery and terminal projects indicates more than seven trains, each a mile long, could soon run through metropolitan areas daily.

Oil companies increasingly are turning to rail shipments of crude oil, responding to the availability of less expensive deposits in North Dakota and Canada. Diane Bailey, a scientist with NRDC, said the state does not yet have safety measures and adequate emergency response plans in place to handle the expected increase.

The NRDC report follows a report Tuesday authorized by the city of Benicia that said a plan for the city’s Valero Refining Co. to run 100 crude oil train cars a day through Sacramento, Roseville, West Sacramento, Davis and other cities is unlikely to cause a spill.

Those trains could begin operation later this year and are expected to run on the rail line shared by the Capitol Corridor passenger train service. That line loops into Sacramento near Business 80, and runs westward along the top of the downtown perimeter, passing through the downtown railyard, then over the I Street Bridge to West Sacramento. It continues through downtown Davis on its way to Benicia.

Acknowledging the growing concern, federal officials have issued warnings about the potential higher flammability of one crude oil type, Bakken oil, and have been exploring implementing tougher safety designs for crude oil tankers to replace the current fleet, which has been deemed inadequate to safely transport volatile crude oils.

In its report, the NRDC called for officials to:

•  Remove antiquated oil tankers from service.

•  Impose lower speed limits on crude oil trains.

•  Reroute trains around sensitive areas.

•  Require railroads to disclose the contents of trains.

•  Make emergency procedures available to local residents.

•  Assess fees on shippers to cover costs of improved emergency response to incidents.

•  Elevate crude oil trains to the highest risk category for hazardous material shipments.

•  Require oil companies to conduct “cumulative risk analysis” for oil rail infrastructure projects, so that the overall impact of all projects is adequately analyzed.

Bakken Crude, Crude By Rail, Derailment, DOT-111, Emergency Readiness & Response, Explosion, Federal Regulation (U.S.), Hazmat notification, Local Regulation, Massive increase in crude-by-rail, Rail inspection, Rail routing, Tank car design, Train speed

NRDC – It Could Happen Here: The Exploding Threat of Crude by Rail in California

Repost from Natural Resources Defense Council
[Editor: Excellent resources….  Be sure to see the downloadable fact sheet and blast zone maps for Bakersfield, Benicia, Davis, Martinez, Pittsburg, Richmond and Sacramento that follow below this article.  – RS]

It Could Happen Here: The Exploding Threat of Crude by Rail in California

Diane Bailey  |  June 18, 2014

Key Points

  • More crude oil was transported by rail in North America in 2013 than in the past five years combined. Millions of Californians live near crude-by-rail routes and could face extreme safety risks.
  • Federal regulators have few safeguards in place to protect communities and the environment from accidents, spills and explosions resulting from the race to move millions of barrels of crude by rail.
  • NRDC calls on lawmakers to expedite rules mandating commonsense practices, including removal of defective tank cars, rerouting around sensitive areas, and requiring disclosure regarding the content of all shipments and relevant risks to local residents.
  • Nearly four million Bay Area and Central/San Joaquin Valley residents are at increased risk from oil train accidents occurring with the proliferation of new crude by rail terminal proposals. But dangerous crude oil train derailments are preventable if the mandatory safety measures NRDC recommends are enacted.

Soda cans on wheels. That’s what some call the dangerous rail tank cars that have suddenly become ubiquitous across the American landscape. In the rush to transport land-locked unconventional new crude oil sources, old rail lines running through communities across America are now rattling with thousands of cars filled with crude oil. Neither the cars nor the railroads were built for this purpose. Worse, federal regulators have few safeguards in place to protect communities and the environment from accidents, spills and explosions resulting from the race to move millions of barrels of crude by rail.

More crude oil was transported by rail in North America in 2013 than in the past five years combined, most of it extracted from the Bakken shale of North Dakota and Montana. In California, the increase in crude by rail has been particularly dramatic, from 45,000 barrels in 2009 to 6 million barrels in 2013. As “rolling pipelines” of more than 100 rail cars haul millions of gallons of crude oil through our communities, derailments, oil spills and explosions are becoming all too common. Between March 2013 and May 2014, there were 12 significant oil train derailments in the United States and Canada. As oil companies profit, communities bear the cost.

Californians Living Near Crude By Rail Routes

A new report from the State of California Interagency Rail Safety Working Group outlines serious vulnerabilities along California rail lines including close proximity to many population centers, numerous earthquake faults, a shortage of adequate emergency response capacity, many areas of vulnerable natural resources, and a number of “high hazard areas” for derailments, which are generally located along waterways and fragile natural resource areas. Millions of Californians live near crude by rail routes and could face extreme safety risks. Currently, there are five major new crude by rail terminals in the planning stages and two recently converted crude oil rail terminals that could collectively bring in up to seven or more mile long trains each day through metropolitan areas like Sacramento, putting up to 3.8 million people in harm’s way.

Explosions and Spills Threaten Lives

“Each tank car of crude holds the energy equivalent of 2 million sticks of dynamite or the fuel in a widebody jetliner,” write Russell Gold and Betsy Morris in the Wall Street Journal. In July 2013, an unattended oil train carrying 72 carloads of crude oil from North Dakota exploded in the center of Lac-Mégantic, Quebec, near the U.S. border. The resulting inferno killed 47 people and destroyed much of the town center. Some 1.6 million gallons of crude oil was spilled. In the months following this devastating event, several more North American oil train derailments illustrated the sobering recurring public safety and environmental threats of catastrophic derailments due to the virtually unregulated surge in crude by rail. In 2013, rail cars spilled more crude oil than nearly the previous four decades combined (1.14 million gallons in 2013 compared to 800,000 gallons from 1975 to 2012).

Communities Lack Information And Control Over Hazardous Rail Shipments

Municipalities across the country are demanding increased communication about rail shipments of crude oil through their communities. However, crude oil — and other hazardous materials shipped by rail — have been exempted from the disclosure requirement of the Emergency Planning and Community Right-to-Know Act (EPCRA). While the federal government finally directed rail companies to disclose this critical information to emergency responders, the general public remains in the dark about the nature of mile long tanker trains hurtling through their backyards at dangerous speed. Nobody has a choice about what gets transported through their community, how dangerous the cargo is, how frequently it goes through or whether it could be rerouted to more remote areas. Of the more than 3.8 million Californians who will be put at risk by proposed new crude by rail terminals, most are unlikely to even be aware of the significant new risks that they face.

Outdated and Dangerous Tank Cars Are Used to Carry Crude

Most of the rail tank cars used to carry flammable liquids, including crude oil are old “DOT-111s,” which are widely known to be unsafe. Speaking at a farewell address at the National Press Club in April 2014, outgoing National Transportation Safety Board (NTSB) chairwoman Deborah Hersman repeated a long-held NTSB position that unmodified DOT-111 tank cars — non-pressurized rail tank cars that accident investigators report are easily punctured or ruptured during a derailment — are not safe to carry hazardous liquids. “Carrying corn oil is fine, carrying crude oil is not,” she said.

Thus, in 2009, the NTSB recommended these tank cars be equipped with additional safety features. Since October 2011, new rail tank cars built for transporting crude oil have incorporated these features, such as the use of head shields, thicker tank material, and pressure-relief devices. Yet regulators have not eliminated the use of the older, unmodified DOT-111 cars for carrying oil — out of 39,000 DOT-111 tank cars now used to carry crude, two-thirds still do not meet these modern safety standards. The Department of Transportation, simply recommended that shippers stop using these cars to transport oil, but they do not require it.

Commonsense Safeguards for Crude-by-Rail Are Overdue

In the longer term, our health depends on cleaner, renewable energy and moving away from fossil fuels. In the immediate term, we must tighten safety regulations on the rail transport of crude oil, or run the risk of devastating consequences. NRDC calls on lawmakers to expedite rules mandating commonsense practices, including but not limited to the following:

  1. Remove Defective, Dangerous Tankers from Crude by Rail Service: The existing fleet of dangerous DOT-111 tank cars must be taken out of crude oil service immediately.
  2. Impose Safer Speed Limits: Crude oil unit trains must adhere to speed limits that significantly reduce the possibility of an explosion in the event of a derailment.
  3. Reroute Around Sensitive Areas: The National Transportation Safety Board recommendation that crude oil trains avoid heavily populated areas and otherwise sensitive areas must become mandatory.
  4. Require Disclosure: Information regarding the content of all shipments and relevant risks and emergency procedures should be made accessible to local residents.
  5. Provide Emergency Responder Resources: States should assess fees on shippers and carriers to fully cover the costs of providing emergency response services and safeguarding the public from oil trains, and ensure that there is adequate emergency response capacity.
  6. Make Additional Operational Safety and Oversight Improvements: Unit trains of crude oil and other hazardous materials should be placed in the highest risk category of Hazmat shipments; and many other operational improvements should be made. Additional inspections of crude oil trains are also critical, including the funding necessary for more rail safety personnel.
  7. Exercise Local Government Powers:
    • Local governments and states can require cumulative risk analysis of crude oil rail infrastructure and increased rail traffic.
    • Local governments should thoroughly evaluate all of the environmental and public health and safety risks of crude oil rail terminals that require land use permits or other forms of local approval.
    • Local governments should reject any new crude oil rail terminals within one mile of sensitive sites such as homes, schools, daycares, and hospitals.

Crude oil train accidents are preventable. All Californians should be calling for the crude oil and rail safety standards listed here.

Read More…

Fact Sheet (PDF)

portable document format

Maps: Crude Oil Train
Derailment Risk Zones
in California